AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |
Back to Blog
![]() The oil change kit for a RANGER 570 Mid-Size or RANGER CREW 570-4 is part number 2202166 for a 2-quart kit and part number 2879323 for 2.5-quart kit.ġ8. Reinstall and tighten the dipstick and the oil fill cap, if applicable.ġ9. Start the engine. Your Polaris Oil Change Kit comes with the correct amount of oil for your vehicle. Torque to 12 ft-lbs (16 Nm).ġ7. Add 2 quarts (1.9 liters) of the recommended oil. The sealing washer is part number 5812232.ġ6. Reinstall the drain plug, using a 6mm Allen socket. The sealing surfaces on drain plug and crankcase should be clean and free of burrs, nicks or scratches. The filter is part number 2540086.ġ5. Install a new sealing washer on the drain plug. Check to make sure the O-ring is in good condition.ġ4. Install the new filter and rotate it clockwise by hand until the filter gasket contacts the sealing surface and then turn it an additional ¾ of a turn. Make sure the old filter O-ring is completely removed.ġ3. Lubricate the O-ring on the new filter with a film of fresh engine oil. ![]() ![]() Do not allow hot oil to contact skin.ġ1. Using an oil filter wrench, turn the filter counter-clockwise to remove it.ġ2. Using a clean dry cloth, clean the filter sealing surface on the crankcase. Caution: Hot oil can cause burns to skin. Tip: Place a rag in the bottom of the drain pan to prevent splashing of oil.ĩ. Using a 6mm Allen socket, remove the drain plug. Allow it to warm up at idle for 2 to 3 minutes.Ĩ. Place a drain pan beneath the engine crankcase. To change the oil and filter, do the following:ġ. Position the vehicle on a level surface in a well-ventilated area.ģ. Start the engine. Access the drain plug from the bottom of the vehicle. The crankcase drain plug is located on the bottom of the crankcase. When changing the oil on your Polaris RANGER 570 Mid-Size or RANGER CREW 570-4, always wear safety glasses and nitrile gloves. Always check and change the oil at the intervals outlined in the Periodic Maintenance Chart in your Owner's Manual. ![]() For MY22 RANGER SP 570, read 2022+ RANGER SP 570 Oil and Filter Change. Note: This article applies only to 2021 and older RANGER 570 Mid-Size and CREW 570-4 models. To learn more about tools, read the Tools and Fasteners Guide. Purchase an engine oil change kit (2.5 quarts) | Purchase an engine oil change kit (2 quarts) This procedure requires the use of engine oil and an engine oil filter. ![]()
0 Comments
Read More
Leave a Reply. |